READ AND SAVE THESE INSTRUCTIONS
Evaporative Vortex Humidifier Owner’s Guide
LEER Y GUARDAR ESTAS INSTRUCCIONES
Guía Del Propietario Del Humidificador Evaporatorio Tipo Vórtice
LISEZ ET CONSERVEZ CES INSTRUCTIONS
Mode D'emploi Humidificateur D'air Par Évaporation Vortex
model: EVAP40
Contents
Important Instructions ........................................................................4
The Vornado Difference......................................................................6
Product Information............................................................................7
Controls...............................................................................................8
Getting Started...................................................................................9
How To Use.......................................................................................10
Cleaning and Maintenance ...............................................................12
Filter Replacement............................................................................13
Automatic Refill Program..................................................................13
Operating Tips..................................................................................14
Troubleshooting ...............................................................................15
Warranty............................................................................................16
Español p. 17
Français p. 31
English
3
IMPORTANT INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USING.
When using electrical appliances, basic precautions should always
† Do Not use this Humidifier on an uneven surface. Always place this
be followed to reduce the risk of fire, electrical shock and injury to
persons, including the following:
product on a firm, flat surface.
† Do Not operate the Humidifier with a damaged cord or plug, after
the Humidifier malfunctions, or has been dropped or damaged in
any manner. If the supply cord is damaged, it must be replaced by
the manufacturer, its service agent or similarly qualified persons in
order to avoid a hazard.
This appliance has a polarized plug (one blade is wider than the
other). To reduce the risk of electric shock, this plug is intended to
fit in polarized outlet only one way. If the plug does not fit fully in
the outlet, reverse the plug. If it still does not fit, contact a qualified
electrician. Do not attempt to defeat this safety feature.
† Do Not run power cord under carpeting.
† Do Not cover cord with throw rugs, runners or similar objects.
Arrange the power cord away from traffic areas, so it will not
become a tripping hazard.
† Do Not place the Humidifier near heat sources such as stoves,
radiators or heaters.
† Do Not pour water through the top Outlet Air Grill on the Power
Head.
† Do Not use undiluted bleach or ammonia, strong detergents,
abrasive cleansers, gasoline, paint thinner or other solvents to clean
this Humidifier. Use only water and mild detergents to perform daily
maintenance on your Humidifier.
† Do Not ATTEMPT TO DISASSEMBLE THE POWER HEAD. DOING
SO WILL VOID YOUR WARRANTY AND COULD CAUSE DAMAGE
AND/OR PERSONAL INJURY. The Power Head contains no user
serviceable parts. If you experience a problem, please see the
limited warranty for information.
† Do Not repeatedly remove and replace the Water Tanks. This will
overfill the Base and water will spill out.
† Humidifiers should be kept away from children and not be placed
in a child’s room without supervision.
† Do read all instructions before using this Humidifier.
† Do turn the Humidifier off if the relative humidity exceeds 60%.
Humidity levels above 60% may allow moisture to build up indoors
and condense on surfaces, where microorganisms can settle and
grow. For accurate humidity readings, use a hygrometer which is
available at most hardware stores and home centers.
† Do unplug the Humidifier prior to moving, cleaning or refilling.
† Do unplug and empty this Humidifier when not in operation.
† Do empty water from the unit if the Humidifier is to be turned off
and left for more than 8 hours, as leaving the water will encourage
the growth of microorganisms. If this happens, thoroughly
clean and disinfect the unit. (Refer to the CLEANING AND
MAINTENANCE.)
† Do remove the Water Tanks first if you need to move the Humidifier
to another location.
† This Humidifier requires periodic cleaning. Refer to the CLEANING
AND MAINTENANCE instructions provided. Do Not clean the
Humidifier in any manner other than as instructed in this manual.
4
English
IMPORTANT INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USING.
† Do use common sense when using this product and/or any electri-
cal appliance. This appliance is not intended for use by persons
(including children) with a reduced physical, sensory or mental capa-
bilities, or lack of experience and knowledge, unless they have been
given supervision or instruction concerning use of the appliance by
a person responsible for their safety. Children should be supervised
to ensure that they do not play with the appliance.
READ AND SAVE THESE INSTRUCTIONS
English
5
Trust.
The Vornado Difference
It is said that trust isn’t given, but earned. For decades Vornado has
been earning the trust of our customers by offering them only the
best. Vornado provides the highest level of performance, coupled
with the highest level of support available. Complete satisfaction
with no exceptions – this is Vornado’s promise to you. If you are not
satisfied for any reason, please contact us. Knowledgeable repre-
sentatives are available at 1-800-234-0604 from 7:00 AM to 6:00 PM
CST. A wealth of additional support is also available online at
Andover, Kansas headquarters – thank you for selecting Vornado.
See it
in action
Sincerely,
Randy Brillhart
Without Adequate Circulation With Vornado Vortex Action
The Vornado Vortex assisted humidifier distributes moisture
farther into the room, enabling faster humidification. By in-
corporating Vornado’s exclusive Vortex Action, the humidifier
moves large volumes of harsh, dry air through two specially
designed filters and circulates the moistened air throughout
the room, providing complete and even humidification.
6
English
Product Information
Vornado® Evap40 Humidifier Parts
While your Vornado® Evaporative Humidifier requires
no assembly, you will need to know how to remove the
Water Tanks and Filters for cleaning, maintenance, and
filter replacement. The components are as follows:
Water Tanks
Power Head
Filters (Behind Grill)
Base
English
7
Controls
B
A
Power, Fan Speed - HI, MED and LO
HUMIDISTAT, MAX to MIN
A
B
HIGH for fast humidification or larger rooms. High speed
operation will evaporate 4.0 gallons of water (+/- 5%) in 24 hours
of continuous operation. (This assumes room conditions of 70˚ F
and 30% relative humidity.)
Set the humidity by turning the knob between MAX and MIN
humidification level. The Humidifier will operate until the desired
humidity level is reached. At this point, the fan will turn off. If
the fan does not turn on, the humidity setting may be lower than
the room humidity level.
MEDIUM for normal operation.
LOW for quiet, nighttime operation or smaller rooms.
8
English
Getting Started
A Humidifier is quite useful in supplying necessary moisture to dry air.
It should be used with proper care to prevent over-humidification. A
good rule of thumb would be to gauge the condensation or frost on
windows. Adjust your Humidifier to a point where this condition is at a
minimum. These adjustments should be made when major changes in
outdoor temperatures occur. Humidifiers can be placed in any living
area that has a location that is convenient and provides distribution of
the moist air to the living area.
Before Operating
When removing the Humidifier from the retail carton, reach
under the Humidifier and lift from the bottom of unit.
Your new Humidifier uses a sizable volume of water, so we
recommend checking the Base and Water Tanks for leaks that
may have occurred due to damage caused in shipping.
Note: A visual inspection may not reveal hairline fractures.
The measured output of a Humidifier is based upon continuous
operation at standard rating conditions. With normal variations of
indoor and outdoor conditions, the Humidistat controlled Humidifier
will not run continuously, at maximum output, unless the controls are
set to do so.
To Check For Leaks:
1. Place Humidifier on a water-resistant surface.
2. Remove the Water Tanks and fill with water to inspect for leaks.
Initial Humidity requirements:
3. Next, pour several cups of water into the Base to inspect for
leaks.
When initially installed or when placed in operation at the beginning
of each season, the Humidifier may run constantly for a day or so and
thus evaporate large quantities of moisture. When the home and its
furnishings have absorbed moisture and become stabilized at the
desired humidity level, the amount of water used will diminish and the
Humidifier operation will maintain the desired humidity level.
Not Leaking?
Empty water from Base and install the full Water Tanks.
Leaking?
In the slight chance your Humidifier has leaks, contact Consumer
Services and we will immediately replace damaged parts.
English
9
How To Use
Filling the Water Tanks
Installing the Water Tanks
1. Place the filled Water Tanks next to the base with the groove in the
Water Tanks resting on the curved edge of the base cavity. Simply
rotate the water Water Tanks into position by tilting the Water Tanks
up. The Water Tanks will begin to dispense water into the base
reservoir just before it nests into its upright position. Proper water
level in the base is continuously maintained. Tanks must be in place
for unit to work correctly.
1. Unplug Humidifier. Place on firm and level surface, such as the
floor.
Note: Spills can occur during cleaning, moving, or refilling Water
Tanks, so be careful to avoid spills when doing these activities.
2. Remove the Water Tanks (A).
B
3. The patented rugged Water Tanks have no caps; no valves, and fit
in most kitchen sinks. Fill the Water Tanks by running cool tap water
into the spout. The built-in, wide-mouth spout and funnel makes
filling easy under most faucets. Each Water Tank is designed to
allow it to sit stable in the sink or on a counter top. (B).
A
10 English
How To Use
Operation
humidifier will run continuously. With the humidistat completely on
the MIN setting,the unit will not operate.
1. Position the unit to not blow directly on objects or plants. Plug the
unit into a 110-120 volt AC outlet.
2. Turn the control full clockwise to the MAX position (maximum
humidity level).
3. To turn the unit On, rotate the fan power speed knob clockwise.
The power indicator light will illuminate. Select a fan speed for the
desired humidification. Use these general guidelines for operation:
HI - operation for fast humidification for larger rooms. High
speed operation will evaporate 4.0 gallons of water (+/- 5%) in 24
hours of continuous operation. (This assumes room conditions
of 70º F and 30% relative humidity.) Unit will operate at High fan
speed until the humidity set point is reached. The Fan will then
turn off until the humidity level drops below set point.
MED - for normal operation.
LO - operation for quiet, nighttime use or smaller rooms. On Low
operation, your Humidifier may run without refilling for extended
periods. Unit will operate at Low fan speed until the humidity
set point is reached. The Fan will then turn off until the humidity
level drops below set point.
4. When the room has reached the desired humidity level, lower the
humidistat slowly (counter-clockwise) until the fan stops. The unit
will automatically restart when the humidity falls below this setting.
Power light will stay lit even when fan has stopped.
Note: With the humidistat on the MAX setting, your Vornado
English 11
Cleaning and Maintenance
Proper cleaning of your Evaporative Vortex Humidifier is essential
to the air quality and performance of your unit. The frequency in
which your Humidifier will need to be cleaned will vary, depending
on use, water hardness, and outside environmental factors. It is
recommended, assuming average use, to thoroughly clean the unit
several times throughout the season, or when algae, mineral deposits
or other particles begin to form.
2. Rinse thoroughly with clean warm water to remove scale and
cleaning solution before disinfecting the Base.
Disinfecting The Base
1. Mix a solution of 1 teaspoon chlorine bleach and 1 gallon of
water. Fill the Base with the solution. Let solution stay 20 minutes,
swishing every few minutes. Wet all surfaces.
1. Turn the Humidifier Off and unplug. Do not submerge in water.
2. Remove the Power Head, Water Tanks and Filters from the base.
1 tsp.
Chlorine Bleach
1 gal.
Water
+
3. Empty the Base and Water Tanks, then rinse with clean tap water.
As noted, depending on the quality of water in your home,
impurities can build up quickly or may take some time. It is possible
that some scale may form on the inside of the Base.
2. Empty Base after 20 minutes. Rinse with water until bleach smell is
To Clean Water Tanks
gone. Dry with clean cloth or paper towel.
1. Mix a solution of one (1) 8 oz. cup of undiluted white vinegar and
1 gallon of water. Fill the Water Tanks with the solution. Seal the
fill spout with the palm of your hand and shake vigorously. Let the
Water Tanks stand for 20 minutes.
3. Dust or vacuum the power head to remove any dust or dirt that
has built up. Do not disassemble
power head for cleaning. It has been
designed to have long life with non-
corrosive thermoplastics and large
tolerances to run clean and quiet
8 oz.
1 gal.
Water
+
without maintenance.
White Vinegar
12 English
Filter Replacement
To Clean Grill
1. Unplug the unit.
The Filters may accumulate minerals and other impurities that occur
naturally in any water supply. While your Humidifier came equipped
with Filters, you will eventually have to replace them, as they last
approximately 4-8 weeks, depending on use. You will know the
Filter needs to be replaced when it becomes hard and is no longer
absorbing the water effectively. Replace the Filters with only genuine
Vornado® brand Filters. While other brands may fit our units, these
filters do not carry the same quality and life as our own and can
diminish the Humidifier’s performance.
Note: Do not use gasoline, thinners, solvents or other chemicals for
cleaning.
2. Use canned compressed air around the top outlet grill and side
inlet grill, follow up using your brush attachment on your household
vacuum cleaner to vacuum top outlet grill and side inlet grill. Wipe
down the entire surface with a soft cloth.
Replacing The Filters
Note: When reinstalling the Filters, Power Head and the Water Tanks,
for proper operation, the Power Head, Base and Water Tanks must be
properly aligned.
1. Turn the unit Off and unplug.
2. Remove the Power Head and discard used Filters.
3. Install new genuine Vornado Filters by laying them at an angle
End Of Season Maintenance
1. Follow instructions at end of humidification season or when
Humidifier will not be used for at least one week or more.
along the open grill, inside of the base.
4. Replace the Power Head, making sure it's properly aligned. Your
Humidifier is now ready for use.
2. Let Humidifier dry completely before storing. Do not store with
water inside Water Tanks or Base.
Automatic Refill Program
3. Remove and discard the Filters if it is not suitable for reuse. Do not
store the Humidifier with wet Filters. If the Filters are suitable for
future use, remove and empty water from the Base and Water Tank.
Replace the Water Tanks, power unit On and select the HIGH Fan
Speed. Allow the unit to run until the Filters are completely dry.
Select the shipment interval and Vornado will
send replacement Filters automatically. Eliminate
the hassle of remembering to reorder. Maintain
the high efficiency of your Vornado Humidifier.
[email protected] or call
4. Store in cool, dry location.
Part # MD1-0002
1-800-234-0604. Cancel at anytime.
English 13
Operating Tips
There are several things to be aware of as your Vornado® Evaporative
Humidifier is operating:
Extending Filter Life
Many factors affect the life of the Filters - including amount of use,
water hardness, and outside environmental factors. Below are tips to
help extend the life of your Filters:
† One of the Water Tanks may empty before the second Water Tank
begins to dispense water. This is normal.
† If you operate your Humidifier continuously, it may need to be
refilled with water every day. Simply look through the Water Tank to
be certain that there is an adequate water supply for operation.
† Protect the Water Tank from damage. Any cracks or damage to the
Tank may cause it to leak water onto the floor or other surfaces.
† On first use, the Filters may give off a mild odor. The odor is not
harmful and will go away after the first few hours of operation. If the
odor is exceptionally strong, you can help eliminate most or all of it
by soaking the Filters for 20 to 30 minutes in a solution of 1 gallon
water to 2 teaspoons white vinegar. Rinse thoroughly.
† If the Humidifier is turned Off, with water in the unit, and not
turned back on for 8 hours or longer, or if the unit is not cleaned
as recommended, you may experience some growth of algae or
bacteria. These microorganisms may become airborne. Thoroughly
clean the unit to eliminate any microorganisms.
1. The additional sodium in chemically softened water may cause
Filters to harden or become mushy. Try using untreated or tap
water.
2. Hard water or water with excessive minerals such as lime or iron
may shorten the Filters life. Try Bacteriostat or Water Treatment
found at most hardware or home specialty stores. Or periodically
remove the Filters and clean, by soaking them in cool tap water
(enough to cover the Filters) and two teaspoons of white vinegar.
Let stand 20 minutes, then rinse in cool water. Allow excess water
to run off and dry before replacing them in the Base. DO NOT
wring.
3. Leaving the Filters too long in a filled Humidifier without the fan
running may cause mold, mildew, and deterioration. If Humidifier is
filled, do not leave it off for more than eight hours.
† Allow for optimum airflow by keeping the grill unobstructed. En-
sure curtains and other items are far enough away from the unit to
not be pulled into the side inlets or interfere with airflow.
† We recommend you operate your Humidifier continuously. This
helps maintain humidity all day long, costs only pennies a day, and
will not harm the unit.
14 English
Troubleshooting
Problem
Possible Cause and Solution
Unit fails to power on.
Unit is not plugged in. Plug power cord into electrical outlet.
Household circuit breaker / ground fault interrupter has tripped or blown a fuse. Reset circuit breaker / ground
fault interrupter, or replace fuse. For assistance, contact a licensed electrician.
Unit is damaged or in need of repair. Cease usage and unplug. Contact Consumer Service for assistance.
This is normal. Water is being dispensed into Base.
Unit makes a bubbling
or gurgling sound.
Unit is not producing
desired amount of
humidity.
Water level in Tank is empty or too low. Refill with clean, cool tap water. (See HOW TO USE for instructions.)
Unit has reached its set point. When set humidity level is reached, the Fan will turn off until humidity level in the
room drops below humidity set point.
Airflow is blocked. Remove obstruction.
Unit settings are too low. Set to High Fan Speed or turn up humidistat for maximum humidity output.
Filters are in need
of replacement too
often.
The additional sodium in chemically softened water may cause Filters to harden or become mushy. Try using
untreated tap water or distilled water.
Try adding Bacteriostat or Water Treatment found at most hardware or home specialty stores to the water. Or
periodically remove the Filters and clean, by soaking them in cool tap water and two teaspoons of white vinegar.
Let stand 20 minutes, then rinse in cool water. Allow excess water to run off and dry before replacing them in the
Base. DO NOT wring.
English 15
Warranty
Evaporative Vortex Humidifier • 5 Year Limited Warranty
Vornado Air LLC (“Vornado”) warrants to the original consumer or purchaser this
Vornado Evaporative Vortex Humidifier (“Product”) is free from defects in material
For warranty or repair service, call 1-800-234-0604 or email
[email protected] to obtain a Return Authorization (“RA”) form. Please have
or include your Product’s model number and serial number, as well as your name, address,
city, state, zip code and phone number when contacting Vornado for warranty service.
After receiving the RA form, ship your Product to:
Vornado Air LLC
®
or workmanship for a period of five (5) years from the date of purchase, depending on
model. If any such defect is discovered within the warranty period, Vornado, at its discre-
tion, will repair or replace the Product at no cost. Repairs not covered by the warranty or
outside the warranty period will require a fee to cover the cost of materials, labor, han-
dling and shipping.
Attn: Warranty & Repair
415 East 13th Street
This warranty does not apply to defects resulting from abuse of the Product, modification,
alteration, repair or service of the Product by anyone other than Vornado, mishandling,
improper maintenance, commercial use of the Product, damages which occur in shipment
or are attributed to acts of God.
Andover, KS 67002
For your convenience, please have your model number and serial number when contact-
ing Vornado with service inquiries. To assure proper handling, packages must be clearly
marked with the RA number. Packages not clearly marked with the RA number may be
refused at the receiving dock.
Please allow 1-2 weeks for repair and return of your Product after the Product is received.
For your records: Staple or attach your original sales receipt to this Owner’s Guide. Please
also write your products’s serial number below (located on product specs decal).
REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLU-
SIVE REMEDY OF THE CONSUMER. VORNADO SHALL NOT BE LIABLE FOR ANY
INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR BREACH OF ANY EXPRESS OR
IMPLIED WARRANTY ON THIS PRODUCT. EXCEPT TO THE EXTENT PROHIBITED BY
APPLICABLE LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE ON THIS PRODUCT IS LIMITED IN DURATION TO THE DURA-
TION OF THIS WARRANTY.
Serial No. ______________________________________
© 2014 Vornado Air LLC Andover, KS 67002
Some states do not allow the exclusion or limitation of incidental or consequential dam-
ages, or allow limitations on how long an implied warranty lasts, so the above limitations
or exclusions may not apply to you. This warranty gives you specific legal rights, and you
may have other rights that vary from state to state.
Specifications subject to change without notice.
®
Vornado is a trademark owned by Vornado Air LLC.
Designed, assembled and supported in Andover, KS.
16 English
Vornado Air, LLC
415 East 13th Street, Andover, Kansas 67002
CL3-0378 R-
CL7-0378 R-, V00
|